新闻动态
储气罐的作用是维持紧凑的空气系统
螺杆式空气压缩机储气罐不能用吗？
Is the storage tank of the screw air compressor unusable?
一位热心人说：空压机出口的储气罐不能只起到出气压力波动、缓冲等作用，同时，还有另外一个普通用户不会注意到的紧张作用，就是，防止空压机停机期间，由于某种原因，压缩空气管路回流液体，灌入空压机内，因其损坏。假设把储气罐移开了，那么在管路设计中，采用倒U形弯头设计也是一样。不知是否正确，请指教一下。
A warm-hearted person said that the air storage tank at the outlet of the air compressor cannot only serve as a buffer for pressure fluctuations and other effects. At the same time, there is another tension that ordinary users will not notice, which is to prevent the compressed air pipeline from flowing back liquid into the air compressor due to certain reasons during the shutdown of the air compressor, which may be damaged. Assuming the air storage tank is moved away, the same applies to the inverted U-shaped elbow design in pipeline design. I don't know if it's correct, please give me some advice.
二：储气罐的作用是维持紧凑的空气系统，管网压力不会出现大的波动。因为紧缩空气系统终结的空间消耗一般不可能在任何时候都稳定下来，所以就需要利用储气罐来平衡系统压力稳定，减少空压机的频繁加载和卸载。另一种方法是再次冷却经过干燥的紧缩空气，以降低紧缩空气中水分的含量。
2： The function of the air storage tank is to maintain a compact air system, and the pressure of the pipeline network will not fluctuate significantly. Because the space consumption at the end of the compressed air system is generally not stable at any time, it is necessary to use an air storage tank to balance the system pressure stability and reduce the frequent loading and unloading of the air compressor. Another method is to cool the dried compressed air again to reduce the moisture content in the compressed air.
对于空气压缩系统，如空气压缩机排量较大(如离心空气压缩)、系统管网体积较大(管道直径较大、管道长度较大)、用气情况较好等情况，也可以不配备储气罐。但是一般的压缩空气系统都需要一个储气罐。
For air compression systems, if the displacement of the air compressor is large (such as centrifugal air compression), the volume of the system pipeline network is large (with a larger diameter and length of the pipeline), and the gas consumption is good, it is also possible to not be equipped with an air storage tank. But general compressed air systems require an air storage tank.
热情洋溢的网友三：空气压缩机内部没有储存紧缩空气的地方，一旦出现紧缩空气就必须用掉，如许的工作方法并不抱负，有了储气罐，可以先把紧缩空气注入储气罐，达到一定的气压，再用到气压下降到一定的高度，再启动，如许无论从动力哄骗角度来说，都比抱负要好。因此，没有储气罐是不可能的。
Enthusiastic Netizen 3: There is no place to store compressed air inside the air compressor, and once compressed air occurs, it must be used. This working method is not ambitious. With an air storage tank, compressed air can be injected into the tank to reach a certain pressure, and then lowered to a certain height before starting. This is better than ambition from the perspective of power deception. Therefore, it is impossible without an air storage tank.
热情洋溢的四位网友：关于所需空空量小，应用不频繁的设备，空压机不能储气罐能。但是考虑到空气压缩机的功能波动、压缩空气的压力不变和质量不变，最好配储气罐。
Enthusiastic four netizens: Regarding equipment that requires small air volume and is not frequently used, air compressors cannot store energy in gas tanks. However, considering the fluctuation of the function of the air compressor, the constant pressure and quality of the compressed air, it is best to install an air storage tank
Is the storage tank of the screw air compressor unusable?
一位热心人说：空压机出口的储气罐不能只起到出气压力波动、缓冲等作用，同时，还有另外一个普通用户不会注意到的紧张作用，就是，防止空压机停机期间，由于某种原因，压缩空气管路回流液体，灌入空压机内，因其损坏。假设把储气罐移开了，那么在管路设计中，采用倒U形弯头设计也是一样。不知是否正确，请指教一下。
A warm-hearted person said that the air storage tank at the outlet of the air compressor cannot only serve as a buffer for pressure fluctuations and other effects. At the same time, there is another tension that ordinary users will not notice, which is to prevent the compressed air pipeline from flowing back liquid into the air compressor due to certain reasons during the shutdown of the air compressor, which may be damaged. Assuming the air storage tank is moved away, the same applies to the inverted U-shaped elbow design in pipeline design. I don't know if it's correct, please give me some advice.
二：储气罐的作用是维持紧凑的空气系统，管网压力不会出现大的波动。因为紧缩空气系统终结的空间消耗一般不可能在任何时候都稳定下来，所以就需要利用储气罐来平衡系统压力稳定，减少空压机的频繁加载和卸载。另一种方法是再次冷却经过干燥的紧缩空气，以降低紧缩空气中水分的含量。
2： The function of the air storage tank is to maintain a compact air system, and the pressure of the pipeline network will not fluctuate significantly. Because the space consumption at the end of the compressed air system is generally not stable at any time, it is necessary to use an air storage tank to balance the system pressure stability and reduce the frequent loading and unloading of the air compressor. Another method is to cool the dried compressed air again to reduce the moisture content in the compressed air.
对于空气压缩系统，如空气压缩机排量较大(如离心空气压缩)、系统管网体积较大(管道直径较大、管道长度较大)、用气情况较好等情况，也可以不配备储气罐。但是一般的压缩空气系统都需要一个储气罐。
For air compression systems, if the displacement of the air compressor is large (such as centrifugal air compression), the volume of the system pipeline network is large (with a larger diameter and length of the pipeline), and the gas consumption is good, it is also possible to not be equipped with an air storage tank. But general compressed air systems require an air storage tank.
热情洋溢的网友三：空气压缩机内部没有储存紧缩空气的地方，一旦出现紧缩空气就必须用掉，如许的工作方法并不抱负，有了储气罐，可以先把紧缩空气注入储气罐，达到一定的气压，再用到气压下降到一定的高度，再启动，如许无论从动力哄骗角度来说，都比抱负要好。因此，没有储气罐是不可能的。
Enthusiastic Netizen 3: There is no place to store compressed air inside the air compressor, and once compressed air occurs, it must be used. This working method is not ambitious. With an air storage tank, compressed air can be injected into the tank to reach a certain pressure, and then lowered to a certain height before starting. This is better than ambition from the perspective of power deception. Therefore, it is impossible without an air storage tank.
热情洋溢的四位网友：关于所需空空量小，应用不频繁的设备，空压机不能储气罐能。但是考虑到空气压缩机的功能波动、压缩空气的压力不变和质量不变，最好配储气罐。
Enthusiastic four netizens: Regarding equipment that requires small air volume and is not frequently used, air compressors cannot store energy in gas tanks. However, considering the fluctuation of the function of the air compressor, the constant pressure and quality of the compressed air, it is best to install an air storage tank